STERLING "G" B-VENT
ahoo! is not affiliated with the authors of this page or responsible for its content.
STERLING G B-VENT
STERLING G B-VENT
(8521)
Gas Fired B-Vent Room Heater
Owners Manual
WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or loss of life.
v Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
v WHAT TO DO IF YOU SMELL
GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use
the phone in your building.
Immediately call your gas supplier from a
neighbors phone. Follow your gas suppliers
instructions.
If you cannot reach your gas supplier, call
the fire department.
v Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.
AVERTISSEMENT: Assurez-vous de bien suivre
les instructions donné dans cette notice pour
réduire au minimum le risque dincendie ou pour
éviter tout dommage matéeriel, toute blessure ou
la mort.
v Ne pas entresposer ni utiliser dessence
niautrevaperurs ou liquides inflammables
dans le voisinage de cet apprareil ou de
tout autre appareil.
v QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter dallumer dappareil.
Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur
de gaz, appelez le service dos incendies.
v
Linstallation et service doit être exécuté par un
qualifié installer, agence de service ou le
fournisseur de gaz.
317 Stafford Avenue
Morrisville, Vermont 05661
E-Mail:
inquiry@hearthstonestoves.com
.
6400-40427 11-24-04
HearthStone Quality Home Heating Products
MODEL Sterling G B-Vent
1
TABLE OF CONTENTS
TABLE OF CONTENTS ................................................................................................................................... 1
Introduction
.................................................................................................................................................. 2
Owner Information Record............................................................................................................................. 3
Warnings - Cautions - Safety Information ..................................................................................................... 4
Unpacking And Inspection................................................................................................................................. 5
Installation And Connections ............................................................................................................................. 6
Hearth Requirements ...................................................................................................................................... 6
Clearances To Combustibles .......................................................................................................................... 7
Electrical Connections .................................................................................................................................... 8
Thermostat.................................................................................................................................................. 8
Venting /Chimney Requirements ................................................................................................................... 8
Normally Aspirated Chimneys ................................................................................................................... 8
Draft Hood/Down Draft Sensor/Spill Switch............................................................................................. 9
Power Venting ............................................................................................................................................ 9
Gas Supply.................................................................................................................................................... 10
Gas Connection ........................................................................................................................................ 10
Gas Pressure Adjustment.......................................................................................................................... 11
Log Placement Within Unit .......................................................................................................................... 11
Log Set Removal...................................................................................................................................... 11
Lighting the Unit for the First Time ............................................................................................................. 12
Lighting Instructions ................................................................................................................................ 13
To Turn Off Gas To Appliance ................................................................................................................ 13
Initial adjustments ........................................................................................................................................ 14
Variable Output Control........................................................................................................................... 14
Air Shutter Adjustments........................................................................................................................... 14
Pilot Adjustments ..................................................................................................................................... 15
Daily Operation................................................................................................................................................ 15
Routine Maintenance and Care ........................................................................................................................ 15
Optional Blower Fan ........................................................................................................................................ 16
Gas Requirements For Blower ..................................................................................................................... 16
Trouble Shooting .............................................................................................................................................. 17
Parts List........................................................................................................................................................... 18
Specifications ................................................................................................................................................... 18
S
AFETY
L
ABEL........................................................................................................................................ 19
E
LECTRICAL
S
CHEMATICS .................................................................................................................. 20
Optional Blower ....................................................................................................................................... 20
LIMITED WARRANTIES
............................................................................................................ 21
HearthStone Quality Home Heating Products
MODEL Sterling G B-Vent
2
I
NTRODUCTION
Congratulations on your purchase of a HearthStone® Sterling gas-fired B-vent fireplace heater.
The Sterling incorporates the latest in energy efficient gas technology which will provide you with
clean, efficient heat for years to come. The combination of natural stones with cast iron gives the
Sterling a pleasing look which can be maintained with minimum care.
To own a HearthStone is to make a statement - a statement of your appreciation and
understanding of exceptional quality. Your Sterling is manufactured using imported cast iron and
stone which combine to enhance the decor of any home. Handcrafted in Vermont, your HearthStone
stove is a fine piece of furniture which will complement any room, even when it is not burning.
However, when your Sterling is burning, it provides the warmth of radiant heat from the granite,
marble and soapstone tiles.
Your Sterling is easy to use too. There is no chopping, hauling or stacking wood; simply adjust
the temperature on your wall-mounted thermostat and it will keep your home at a comfortable
temperature throughout the year.
Welcome to the HearthStone® family.
Please read this manual carefully to familiarize yourself with the safe installation, operation, and
maintenance of your Sterling. Should you have any questions, do not hesitate to contact your
HearthStone Dealer.
Certified for use by:
Board of State Examiners of Plumbers and Gasfitters
100 Cambridge Street, Room 1511
Boston, Massachusetts
02202
HearthStone Quality Home Heating Products
MODEL Sterling G