ck>Yahoo! is not affiliated with the authors of this page or responsible for its content.
MATERIAL SAFETY DATA SHEET EQUILON MSDS: 00600ET 01/04/99 TRANSFORMER OIL TELEPHONE NUMBER: 24 HOUR EMERGENCY ASSISTANCE GENERAL MSDS ASSISTANCE EQUIVA SERVICES: 877-276-7283 877-276-7285 CHEMTREC: 800-424-9300 NAME AND ADDRESS: EQUILON ENTERPRISES LLC PRODUCT STEWARDSHIP P.O. BOX 674414 HOUSTON, TX 77267-4414 LEGEND: N.D. - NOT DETERMINED N.A. - NOT APPLICABLE N.T- NOT TESTED < - LESS THAN > - GREATER THAN ________________________________________________________________________________ 1.NAME ________________________________________________________________________________ MATERIAL IDENTITY Product Code and Name: 00600 TRANSFORMER OIL Chemical Name and/or Family or Description: Transformer Oils _______________________________________________________________________________ 2. COMPOSITION/INFORMATION ON INGREDIENTS _______________________________________________________________________________ THE CRITERIA FOR LISTING COMPONENTS IN THE COMPOSITION SECTION IS AS FOLLOWS: CARCINOGENS ARE LISTED WHEN PRESENT AT 0.1 % OR GREATER; COMPONENTS WHICH ARE OTHERWISE HAZARDOUS ACCORDING TO OSHA ARE LISTED WHEN PRESENT AT 1.0 % OR GREATER; NON-HAZARDOUS COMPONENTS ARE LISTED AT 3.0 % OR GREATER. THIS IS NOT INTENDED TO BE A COMPLETE COMPOSITIONAL DISCLOSURE. REFER TO SECTION 14 FOR APPLICABLE STATES' RIGHT TO KNOW AND OTHER REGULATORY INFORMATION. Product and/or Component(s) Carcinogenic According to: OSHA IARC NTP OTHER NONE X _ _ _ _ _ Composition: (Sequence Number and Chemical Name) Seq. Chemical Name CAS Number Range in % ____ ____________________________________________ ______________ ____________ 01 # Hydrotreated light naphthenic petroleum 64742-53-6 95.00-99.99 distillates PRODUCT IS NON-HAZARDOUS ACCORDING TO OSHA (1910.1200), BUT IS CONSIDERED HAZARDOUS ACCORDING TO INTERNAL CRITERIA. # COMPONENT, BY DEFINITION, IS CONSIDERED HAZARDOUS ACCORDING TO OSHA BECAUSE IT CARRIES THE PERMISSIBLE EXPOSURE LIMIT (PEL) FOR MINERAL OIL MIST. Exposure Limits referenced by Sequence Number in the Composition Section Seq. Limit ____ _________________________________________________________________________ 01 5 mg/m3 TWA-OSHA (MINERAL OIL MIST) 01 5 mg/m3 TWA-ACGIH (MINERAL OIL MIST)
MATERIAL SAFETY DATA SHEET
EQUILON MSDS: 00600ET 01/04/99
TRANSFORMER OIL
TELEPHONE NUMBER:
24 HOUR EMERGENCY ASSISTANCE GENERAL MSDS ASSISTANCE
EQUIVA SERVICES: 877-276-7283 877-276-7285
CHEMTREC: 800-424-9300
NAME AND ADDRESS:
EQUILON ENTERPRISES LLC
PRODUCT STEWARDSHIP
P.O. BOX 674414
HOUSTON, TX 77267-4414
LEGEND:
N.D. - NOT DETERMINED N.A. - NOT APPLICABLE N.T- NOT TESTED
< - LESS THAN > - GREATER THAN
________________________________________________________________________________
1.NAME
________________________________________________________________________________
MATERIAL IDENTITY
Product Code and Name:
00600 TRANSFORMER OIL
Chemical Name and/or Family or Description:
Transformer Oils
_______________________________________________________________________________
2. COMPOSITION/INFORMATION ON INGREDIENTS
_______________________________________________________________________________
THE CRITERIA FOR LISTING COMPONENTS IN THE COMPOSITION SECTION IS AS FOLLOWS:
CARCINOGENS ARE LISTED WHEN PRESENT AT 0.1 % OR GREATER; COMPONENTS WHICH ARE
OTHERWISE HAZARDOUS ACCORDING TO OSHA ARE LISTED WHEN PRESENT AT 1.0 % OR
GREATER; NON-HAZARDOUS COMPONENTS ARE LISTED AT 3.0 % OR GREATER. THIS IS NOT
INTENDED TO BE A COMPLETE COMPOSITIONAL DISCLOSURE. REFER TO SECTION 14 FOR
APPLICABLE STATES' RIGHT TO KNOW AND OTHER REGULATORY INFORMATION.
Product and/or Component(s) Carcinogenic According to:
OSHA IARC NTP OTHER NONE
X
_ _ _ _ _
Composition: (Sequence Number and Chemical Name)
Seq. Chemical Name CAS Number Range in %
____ ____________________________________________ ______________ ____________
01 # Hydrotreated light naphthenic petroleum 64742-53-6 95.00-99.99
distillates
PRODUCT IS NON-HAZARDOUS ACCORDING TO OSHA (1910.1200), BUT IS CONSIDERED
HAZARDOUS ACCORDING TO INTERNAL CRITERIA.
# COMPONENT, BY DEFINITION, IS CONSIDERED HAZARDOUS ACCORDING TO OSHA
BECAUSE IT CARRIES THE PERMISSIBLE EXPOSURE LIMIT (PEL) FOR MINERAL OIL
MIST.
Exposure Limits referenced by Sequence Number in the Composition Section
Seq. Limit
____ _________________________________________________________________________
01 5 mg/m3 TWA-OSHA (MINERAL OIL MIST)
01 5 mg/m3 TWA-ACGIH (MINERAL OIL MIST) 01 10 mg/m3 STEL ACGIH (MINERAL OIL MIST)
_______________________________________________________________________________
3. HAZARD IDENTIFICATION
_______________________________________________________________________________
EMERGENCY OVERVIEW
Appearance:
Bright and clear liquid
Odor:
Oil-type odor
WARNING STATEMENT
_________________
CAUTION ! ASPIRATION HAZARD IF SWALLOWED -
CAN ENTER LUNGS AND CAUSE DAMAGE
HMIS NFPA
Health: 1 Reactivity: 0 Health: 1 Reactivity: 0
Flammability: 1 Special : - Flammability: 1 Special : -
POTENTIAL HEALTH EFFECTS
EYE SKIN INHALATION INGESTION
Primary Route of Exposure: X X X
_ _ _ _
EFFECTS OF OVEREXPOSURE
Acute:
Eyes:
May cause minimal irritation, experienced as temporary discomfort.
Skin:
Brief contact may cause slight irritation. Prolonged contact, as with
clothing wetted with material, may cause more severe irritation and dis-
comfort, seen as local redness and swelling.
Other than the potential skin irritation effects noted above, acute (short
term) adverse effects are not expected from brief skin contact; see other
effects, below, and Section 11 for information regarding potential long
term effects.
Inhalation:
Vapors or mist, in excess of permissible concentrations, or in unusually
high concentrations generated from spraying, heating the material or as
from exposure in poorly ventilated areas or confined spaces, may cause
irritation of the nose and throat, headache, nausea, and drowsiness.
Ingestion:
If more than several mouthfuls are swallowed, abdominal discomfort, nausea,
and diarrhea may occur. Aspiration may occur during swallowing or vomiting
resulting in lung damage.
Sensitization Properties:
Unknown.
Chronic:
No adverse effects have been documented in humans as a result of chronic
exposure. Section 11 may contain applicable animal data.
Medical Conditions Aggravated by Exposure:
Because of its defatting properties, prolonged and repeated skin contact
may aggravate an existing dermatitis (skin condition).
Other Remarks:
None
_______________________________________________________________________________ 4. FIRST AID MEASURES
_______________________________________________________________________________
Eyes:
Flush eyes with plenty of water for several minutes. Get medical
attention if eye irritation persists.
Skin:
Wash skin with plenty of soap and water for several minutes. Get medical
attention if skin irritation develops or persists.
Ingestion:
If person is conscious and can swallow, give two glasses of water (16 oz.)
but do not induce vomiting. If vomiting occurs, give fluids again. Have
medical personnel determine if evacuation of stomach or induction of
vomiting is necessary. Do not give anything by mouth to an unconscious or
convulsing person.
Inhalation:
If irritation, headache, nausea, or drowsiness occurs, remove to fresh air.
Get medical attention if breathing becomes difficult or respiratory
irritation persists.
Other Instructions:
Aspiration of this product during induced emesis may result in severe lung
injury. If evacuation of stomach is necessary, use method least likely to
cause aspiration, such as gastric lavage after endotracheal intubation.
Contact a Poison Center for additional treatment information.
Remove and dry-clean or launder clothing soaked or soiled with this
material before reuse. Dry cleaning of contaminated clothing may be
more effective than normal laundering. Inform individuals responsible for
cleaning of potential hazards associated with handling contaminated
clothing.
_______________________________________________________________________________
5. FIRE-FIGHTING MEASURES
_______________________________________________________________________________
Ignition Temperature - AIT (degrees F):
Not determined.
Flash Point (degrees F):
295 (COC)
Flammable Limits (%):
Lower: Not determined.
Upper: Not determined.
Recommended Fire Extinguishing Agents And Special Procedures:
Use water spray, dry chemical, foam, or carbon dioxide to extinguish
flames. Us