owspan=2 width=10 nowrap> « back to results for ""
Below is a cache of http://www.ctbinc.com/PDFfiles/2008lit/CT-2224-1207HeaterforHogsEM.pdf. It's a snapshot of the page taken as our search engine crawled the Web.
The web site itself may have changed. You can check the current page or check for previous versions at the Internet Archive. Yahoo! is not affiliated with the authors of this page or responsible for its content.
Environmental Series
Environmental Series ULTRA-HP Heater for Hogs
Gas pipe layout assistance is available
to customers through authorized
distributors.
Low-Profile
Suspension Shown
Capacity
Maximum per hour
17,000 BTU4,284 Kcal
Gas Consumption (maximum)
LP
.19 gph
.72 l/h
Natural Gas
16.2 cfh
.46 m
3
/h
Gas Pressure Requirements (measured at gauge on manifold)
Maximum
5 PSI
350 Mbar
Heater Dimensions
Weight per Complete Unit
15-19 lbs.
6.8-8.6 kg
Width
24 in.
61 cm
Height (with Low Profile
13.5 in.
34.3 cm
suspension)
Operational Guidelines for Heating Area*
Heating area per unit
200-350 sq. ft.
18.6-32.5 m
2
Height from floor
30-36 in.
76.2-91.4 cm
(measure from edge of canopy)
Space between heaters
10-20 ft.
3.0 - 6.1 m
Minimum Clearance to Combustibles
Sides of heater
36 in.
91.4 cm
Above heater
14 in.
35.6 cm
Below heater
26 in.
66.0 cm
* Adjust up or down depending on housing construction and climate.
Chore-Time ULTRA-HP Heater
Specifications
Reliable, Efficient Radiant Heating
Reliable Heat Distribution
Design is backed by 80 years of experience in heater
innovation and design.
Operate with higher gas pressures to save piping costs
ideal for retrofit in houses with small gas piping.
Maximum Fuel Efficiency
Efficient infrared heating uses less fuel because the floor
stays warm at cooler room temperatures.
Easy to Clean and Maintain
Designed for easy cleaning and maintenance with no tools
and minimal hardware removal. Drop-down orifice for
cleaning, and no air inlet filter or pilot to maintain.
Stainless steel emitter and inner cone protect internal fiber
insulator during power washing (be sure to cover the
control before power washing). Units may also be cleaned
using compressed air.
Control
Zone control allows one thermostat or control to regulate
all heaters in a specified area using a thermostat or
Chore-Times CHORE-TRONICS Control. One manifold
per zone controls up to 20 heaters per zone. Available with
step rate control or modulating. 120 VAC (220/240 VAC 50
or 60 Hz) required.
CSA (Canadian Standards
Association) approved models
available. All models meet CSA
standards for low
carbon monoxide.
The policy of Chore-Time is one of continuous product improve-
ment. We reserve the right to alter specifications without prior
notice. Heating products should be installed only in accordance
with local laws, codes and regulations. These products are not for
residential use.
Manifold for
ULTRA-HP Heater CT-2224/1207
Environmental Series DURA-THERM Space Heater for Hogs
Gas pipe layout assistance is available to
customers through authorized distributors.
High-BTU Output Convection Heating
Reliable Heat Distribution
Design is backed by 80 years of experience in heater
innovation and design.
Durable galvanized steel cabinet with stainless steel option
and heat-resistant aluminized burn chamber.
Maximum Fuel Efficiency
High-performance cast-iron burner provides efficient
combustion.
Multiple ignition and fuel source options.
Easy to Clean and Maintain
Removable panels and controls compartment are
designed for easy cleaning and maintenance. Compressed
air cleaning is recommended do not power wash.
Heats an average of 2500 to 4000 square feet
(232.3 to 371.6 square meters) per heater.
Outside Mount Kit permits unit to be
mounted outside the house draws in
more fresh air, uses less space in house
and adds less in-house humidity.
CSA (Canadian Standards Association)
approved models available. All models
meet CSA standards for low
carbon monoxide.
The policy of Chore-Time is one of continuous product improvement. We reserve the
right to alter specifications without prior notice. Heating products should be installed
only in accordance with local laws, codes and regulations. These products are not for
residential use.
Capacity (maximum per hour)
225,000 BTU (56,700 Kcal) - LP
Pilot, Direct Spark or Hot Surface Ignition
200,000 BTU (50,400 Kcal) - Nat. Gas
Gas Consumption (maximum) - LP
Pilot Ignition
2.48 gph (9.39 l/h)
Direct Spark or Hot Surface Ignition
2.46 gph (9.31 l/h)
Gas Consumption (maximum) - Natural Gas
Pilot Ignition
215.7 cfh (6.11 m
3
/h)
Direct Spark or Hot Surface Ignition
213.8 cfh (6.05 m
3
/h)
Gas Pressure Requirements (measured at inlet)
LP
11" WC (27.5 Mbar)
Natural Gas
7" WC (17.5 Mbar)
Heater Size, Weight & Assembly Information
Heating area per unit
2500-4000 sq. ft. (232.3-371.6 m
2
)
Weight per Complete Unit
125 lbs. (56.7 kg)
Height x Length x Width
30 x 24.5 x 19 inches
(76.2 x 62.2 x 48.3 cm)
Minimum Clearance to Combustibles
Above, below and beside unit
20 in. (50.8 cm)
Exhaust outlet
120 in. (304.8 cm)
Electrical Requirements: 120 VAC (220/240 VAC 50 or 60 Hz)
Chore-Time DURA-THERM Heater Specifications
Hog Production Systems 800.341.1039 or 574.658.4101
www.choretimehog.com E-Mail: hog@choretime.com
PigTek
PART OF PIGTEK
PIG EQUIPMENT GROUP
A DIVISION OF CTB, INC.